Product ID:ROYCO 308 A
MSDS Date:03/30/1994
FSC:9150
NIIN:00-261-8146
MSDS Number: BXVPH

ROYAL LUBRICANTS CO INC

MERRY LANE
EAST HANOVER, NJ 07936
US

Emergency Phone: 201-887-7411/800-424-9300

Info Phone: 201-887-7410

Cage: 6V632

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

MINERAL OIL/HYDROTREATED LIGHT NAPHTHENIC DISTILLATE

CAS: 64742-53-6

RTECS: PY8036000

Fraction By Weight: 85 - 95%

OSHA PEL 5 MG/M3 (OIL MIST)

ACGIH TLV: 5 MG/M3 (OIL MIST)

HYDROTREATED MIDDLE PETROLEUM DISTILLATE

CAS: 64742-46-7

RTECS: JN9379645

Fraction By Weight: 1 - 5%

OSHA PEL 5 MG/M3 AS OIL MIST

ACGIH TLV: 5 MG/M3 AS OIL MIST

MINOR ADDITIVES

Fraction By Weight: <4%

BARIUM DINONYLNAPHTHALENE SULFONATE

CAS: 25619-56-1

Fraction By Weight: 1 - 2%

LD50 LC50 Mixture:TLV FOR OIL MIST IS 5 MG/M3.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYE:IRRITATION. SKIN:PROLONGED/REPEATED CONTACT
MAY CAUSE IRRITATION, DERMATITIS, OIL ACNE. INHALE:VAPORS OR MISTS
MAY CAUSE MILD RESPIRATORY T RACT IRRITATION. ORAL:MAY CAUSE
VOMITING. ASPIRATION HAZARD. CHRONIC- DERMATITIS.
Explanation of Carcinogenicity:WARNING! USED MOTOR OILS WERE SHOWN TO
CAUSE SKIN CANCER WHEN REPEATEDLY APPLIED TO MICE WITHOUT CLEANING
SKIN.
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, DERMATITIS
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS OR IMPAIRED RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE
TO THE EFFECTS OF THIS PRODUCT.

First Aid:GET MEDICAL HELP IF SYMPTOMS PERSIST. INHALED:REMOVE TO FRESH
AIR. PROVIDE CPR/OXYGEN IF NEEDED. EYES:FLUSH WITH WATER FOR 15
MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP & WATER. ORAL:DO
NOT IN DUCE VOMITING. SEEK MEDICAL ATTENTION. IF SPONTANEOUS
VOMITING OCCURS, KEEP VICTIM'S HEAD BELOW HIS HIPS TO PREVENT
ASPIRATION.

Flash Point Method:COC
Flash Point:>300F,>149C
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL/CARBON DIOXIDE. DON'T
USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS.

Spill Release Procedures:SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH &
SHOVELD INTO CONTAINERS. PREVENT RUN-OFF TO ENTER WATERWAYS,
SEWERS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN A COOL, DRY PLACE AWAY FROM
FLAMES & INCOMPATIBLE MATERIALS. KEEP CONTAINER CLOSED.
Other Precautions:"EMPTY" CONTAINERS RETAIN RESIDUE. ALL PRECAUTIONS
SHOULD BE OBSERVED. WASH THOROUGHLY AFTER HANDLING. KEEP OUT OF
REACH OF CHILDREN. AVOID BREATHING MISTS/VAPORS. AVOID REPEATED
SKIN CONTACT. DO NOT GET IN EYES. DO NOT INGEST.

Respiratory Protection:NON REQUIRED UNDER NORMAL CONDITIONS. IF HIGH
VAPOR OR MIST CONCENTRATIONS EXPECTED, USE NIOSH APPROVED CHEMICAL
CARTRIDGE RESPIRATOR FOR ORGANIC VAPORS AND MISTS. REFER TO 29 CFR
1910.134.
Ventilation:USE ADEQUATE VENTILATION TO KEEP OIL MISTS OF THIS MATERIAL
BELOW APPLICABLE STANDARD(S).
Protective Gloves:NITRILE IF FREQUENT CONTACT EXPECTED
Eye Protection:SAFETY GOGGLES IF SPLASHING ANTICIPATED
Other Protective Equipment:EYE WASH STATION AND SAFETY SHOWER.
INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTED AND
VOMITING HAS NOT OCCURED, EMESIS SHOULD BE INDUCED WITH
SUPERVISION. KEEP VICTIM'S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS
LOSS OF GAG REFLEX, CONVULSION OR UNCONSCIOUSNESS OCCUR, GASTRIC
LAVAGE USING A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:V6
NRC/State Lic Num:NOT RELEVANT
Spec Gravity:0.88
Viscosity:12 CS @104F
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER OIL - SLIGHT HYDROCARBON ODOR

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:EXTREME HEAT, FLAMES
Hazardous Decomposition Products:A COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES & GASES WILL EVOVLE. CARBON MONOXIDE & OTHER
COMPD. MAY FORM.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL STATE AND
FEDERAL REGULATIONS. PRODUCT IS AN OIL. SPILLS TO US SURFACE WATERS
OR WATERCOURSE OR SEWER THAT CAUSE A VISIBLE SHEEN MUST BE REPORTED
TO THE NATIONAL RE SPONSE CENTER. RCRA PHONE: 800-424-9346.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.